林德叉车蓄电池作为林德叉车配件重要组成部分，价格高昂，必须严格遵守林德叉车电瓶使用维护说明书，否则不正确的使用方法会影响林德蓄电池组的寿命。贝朗斯叉车蓄电池可为林德叉车动力配套，设计寿命长，符合林德叉车安装标准，分DIN、BS两大系列，德国核心技术，拥有超越10%的赋予容量，避免过度放电，贝朗斯品牌延续欧美叉车蓄电池设计风格，全部软连接，维护方便，外形美观， 蓄电池自放电的主要原因是由于极板含有杂质，形成局部的小电池，而小电池的两极又形成短路回路，引起蓄电池自放电。另外，由于蓄电池电解液上下的密度不同，致使极板上下的电动势不均等，这也会引起叉车电池的自放电。电池活性物质添加剂、隔板、硫酸电解液中的有害杂质含量偏高，是使电池自放电高的重要原因。还应注意的是：当电池电解液中还有某些可变价态的盐类如铁、络、锰盐等，会引起正、负极自放电的连续进行。叉车电池由于采用更加精纯的原副材料，其自放电速率很小，在25～45℃环境温度下，每天自放电量平均为0.1%左右。温度越低，自放电越小，所以说低温条件有利于电池储存。 林德蓄电池组车型配置表概括林德叉车所有电瓶型号，可在贝朗斯动力商城查询，不同容量的价格不一样， 充电过程中蓄电池会产生气体，应保持充电场所通风良好，周围没有明火，同时充电过程中产生的氧气、酸性气体将对周围产生影响。充电期间拔下充电插头会产生电弧，将充电机关闭后，方可拔下插头。充电后在蓄电池周围滞留许多氢气，不允许有任何明火，应开启蓄电池上的盖板进行充电。 贝朗斯公司拥有林德叉车蓄电池技术设计图纸，全国各地可实行免费配送，快捷高效为企业提供更优质的服务。林德蓄电池必须及时补水， 只有补充适量的蒸馏水，才能保持电解液的正常充放电功能，保持电动叉车电池的使用寿命。如果补充的是普通的水，其中所含杂质会在电极沉积，造成充电不足甚至无法充电，所以必须使用蒸馏水。一般干水的话，会导致极板烧毁，短路，电动叉车蓄电池的活性物质会脱落。电动叉车蓄电池失水是因为充电时电池正极析出氧气、负极析出氢气，即部分电能消耗在电解水。特别在过充电时非常严重。电动叉车蓄电池失水，会造成电池极板不可逆硫酸盐化，使电池容量减小，严重的导致电池报废。Linde forklift battery as an important part of Linde forklift accessories high price, must strictly abide by the instructions of Linde forklift battery, or improper use will affect the Linde battery life. Berans for the Linde forklift battery power supporting design, long service life, with Linde installation standards, DIN, BS two series, Germany core technology, has more than 10% given capacity, to avoid excessive discharge, shell lens brand extension Europe forklift battery design , all soft connection, convenient maintenance, beautiful appearance. The main reason is because the battery self discharge electrode containing impurities, forming a small local battery, and the two poles of the battery and the formation of a short circuit, causing the battery self discharge. In addition, because the density of the upper and lower density of the electrolyte is different, the electromotive force on the plate is not equal, which will cause the self discharge of the forklift battery. The content of harmful impurity in battery, active substance, additive, separator and sulfuric acid electrolyte is on the high side, which is the important reason for high self discharge of battery. It should also be noted that when the battery electrolyte, there are certain variable valence salts, such as iron, iron, manganese, salt, etc., will cause positive and negative discharge from the continuous. Due to the use of more pure battery forklift vice material, its self discharge rate is very small, at 25 ~ 45 C ambient temperature, self discharge per day for an average of about 0.1%. The lower the temperature, the smaller the discharge rate, so the low temperature is good for battery storage.
Linde battery vehicle configuration listsummary Linde forklift battery all models, can be found in the shell lens power mall, different capacity price is not the same, in the process of charging the battery will produce gas, should keep well ventilated places charge no fire around, and the charge generated in the process of oxygen, acid gas will have an impact on the surrounding. During charging, pulling out the charging plug causes an arc. After the charger is closed, the plug can be pulled out. After charging, many hydrogen gas is trapped around the battery, and no open flame is allowed. The cover plate on the battery shall be charged.
Bei Langsi company has Linde forklift battery technology design drawings, the country can implement free delivery, fast and efficient for enterprises to provide more quality services. Linde battery must be timely replenishment, only add a proper amount of distilled water, in order to maintain the normal electrolyte charging and discharging function, to maintain the electric forklift battery life. If ordinary water is added, where impurities are deposited on the electrode, resulting in insufficient charge or even charging, distilled water must be used. Generally dry water, will lead to plate burning, short circuit, electric forklift battery active substances will fall off. The electric forklift battery is dehydrated because the positive electrode of the battery releases oxygen and the negative electrode releases hydrogen, that is, part of the electric energy is consumed in the electrolysis water. Especially when charging is very serious. Electric forklift battery water loss, will cause the battery plate irreversible sulfuric acid, so that the battery capacity decreased, leading to serious battery scrap.